Car heating system VW Transporter T4
Heating system device
Heating system device 1. Hood grille; 2. Front intake pipes; 3. Gasket; 4. Rear inlets (on the cross wall); 5. Right air duct; 6. Instrument panel; 7. Right air deflector; 8....
Heating system device 1. Hood grille; 2. Front intake pipes; 3. Gasket; 4. Rear inlets (on the cross wall); 5. Right air duct; 6. Instrument panel; 7. Right air deflector; 8....
Inlet pipes — removal and installation
Front inlets 1. Front inlet; 2. Gasket; 3. Rear inlet Removing 1. Open the bonnet. 2. Unscrew the screws (arrow). 3. Unscrew the intake pipes from the hood. 4. Remove gasket if...
Front inlets 1. Front inlet; 2. Gasket; 3. Rear inlet Removing 1. Open the bonnet. 2. Unscrew the screws (arrow). 3. Unscrew the intake pipes from the hood. 4. Remove gasket if...
Heater motor — removal and installation
Removing 1. Disconnect ground cable (-) from the battery. Attention! At the same time, the anti-theft code is erased from the radio's memory. The battery must not be disconnected...
Removing 1. Disconnect ground cable (-) from the battery. Attention! At the same time, the anti-theft code is erased from the radio's memory. The battery must not be disconnected...
Air deflectors — removal and installation
Removing 1. turning part (2) air deflector (1) take out with a screwdriver. 2. unscrew the screw (the middle deflector has 2 screws) and take out the body (1). 3. Unscrew the...
Removing 1. turning part (2) air deflector (1) take out with a screwdriver. 2. unscrew the screw (the middle deflector has 2 screws) and take out the body (1). 3. Unscrew the...
Heating regulator — removal and installation
Heating regulator Removing 1. Remove control knobs from levers (4). 2. Remove shield (3). 3. Unscrew from instrument panel (2) screws. 4. Drown regulator (1) into the instrument...
Heating regulator Removing 1. Remove control knobs from levers (4). 2. Remove shield (3). 3. Unscrew from instrument panel (2) screws. 4. Drown regulator (1) into the instrument...
Heater control cables — removal and installation
Removing 1. Remove heating controller. 2. Disconnect the cables from the control levers and remove, having removed the plate clamps of the cable sheaths with a screwdriver....
Removing 1. Remove heating controller. 2. Disconnect the cables from the control levers and remove, having removed the plate clamps of the cable sheaths with a screwdriver....
Additional heat exchanger — removal and installation
Removing the additional motor and heater radiator 1. Grille, in the cabin; 2. Gasket; 3. Additional radiator; 4. Coolant supply; 5. Coolant return The additional heater core is...
Removing the additional motor and heater radiator 1. Grille, in the cabin; 2. Gasket; 3. Additional radiator; 4. Coolant supply; 5. Coolant return The additional heater core is...
Additional heating system on the model «Caravel»
Additional heating system on the model "Caravel" 1. Air deflector; 2. Frame-seal; 3. Gasket; 4. Air distributor housing; 5. Heater motor; 6. Coolant tube; 7. Tee; 8. Coolant...
Additional heating system on the model "Caravel" 1. Air deflector; 2. Frame-seal; 3. Gasket; 4. Air distributor housing; 5. Heater motor; 6. Coolant tube; 7. Tee; 8. Coolant...
Diagnosis of malfunctions of the heating system
Cause Elimination Method Heater motor not working Defective heater motor fuse Check motor fuse, replace if necessary Faulty heater motor switch, contacts corroded Check for...
Cause Elimination Method Heater motor not working Defective heater motor fuse Check motor fuse, replace if necessary Faulty heater motor switch, contacts corroded Check for...
This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian
Similar sections from other manuals for VW cars:
Body: Heating system Volkswagen Passat B3 (1988-1993)
Body: Heating and ventilation Volkswagen Golf 1 (1974-1984, diesel)
Electrical equipment: Heating and air conditioning Volkswagen Tiguan 1 (2007-2015)
Body: Heating system Volkswagen Passat B3 (1988-1993)
Body: Heating and ventilation Volkswagen Golf 1 (1974-1984, diesel)
Electrical equipment: Heating and air conditioning Volkswagen Tiguan 1 (2007-2015)
Transporter T4
Transporter T3
- General information
- User manual
- Maintenance
- Power unit
- Engine repair
- Ignition system
- Lubrication system
- Cooling system
- Fuel system (petrol)
- Fuel system (diesel)
- Injection system (petrol)
- Exhaust system
- Transmission
- Clutch
- Car gearbox
- Chassis
- Car suspension
- Steering
- Brake system
- Wheels and tires
- Body
- Exterior
- Interior
- Doors and windows
- Heating system
- Electrical equipment
- Equipment and devices
- Lighting and signaling
- Power devices
- Electrical circuits
- General information
- Maintenance
- Petrol engines
- Engine repair
- Lubrication system
- Cooling system
- Power and exhaust system
- Carburetor 34 PICT
- Carburetors 2E3 and 2E4
- Fuel injection system
- Ignition system
- Diesel engines
- Engine repair
- Lubrication system
- Cooling system
- Power and exhaust system
- Transmission
- Clutch
- Car gearbox
- Chassis
- Front suspension
- Rear suspension
- Steering
- Brake system
- Body
- Body and interior elements
- Doors, locks and windows
- Electrical equipment
- Lighting system
- Equipment and devices
- Power devices (diesel)
- Power devices (petrol)
- Wiring diagrams (diesel)
- Wiring diagrams (petrol)
VWmanual.ru © 2016-2024 | Mobile version | News and articles | Sitemap: EN BG BY UA RS HR RO PL SK HU | Write message | Site search
Passat B2 • Passat B3 • Passat B4 • Passat B5 • Passat B6 • Golf 1, diesel • Golf 1, petrol • Golf 2, petrol • Golf 2 • Golf 3 • Golf 4 • Golf 5 • Polo 3 • Polo 4 • Touareg 1 • Tiguan 1 • Sharan 1 • Transporter T3 • Transporter T4 • Beetle • Caddy 3 •
Passat B2 • Passat B3 • Passat B4 • Passat B5 • Passat B6 • Golf 1, diesel • Golf 1, petrol • Golf 2, petrol • Golf 2 • Golf 3 • Golf 4 • Golf 5 • Polo 3 • Polo 4 • Touareg 1 • Tiguan 1 • Sharan 1 • Transporter T3 • Transporter T4 • Beetle • Caddy 3 •